Boeing 727

The Boeing 727 is an American narrow-body airliner that was developed and produced by Boeing Commercial Airplanes. After the heavy 707 quad-jet was introduced in 1958, Boeing addressed the demand for shorter flight lengths from smaller airports. On December 5, 1960, the 727 was launched with 40 orders each from United Airlines and Eastern Air Lines. The first 727-100 rolled out November 27, 1962, first flew on February 9, 1963, and entered service with Eastern on February 1, 1964.

Boeing 727
A stretched 727-200 of Iberia
Role	Narrow-body jet airliner
National origin	United States
Manufacturer	Boeing Commercial Airplanes
First flight	February 9, 1963^[1]
Introduction	February 1, 1964, with Eastern Air Lines
Status	In limited service for freighter and executive use^[a]
Primary users	Líneas Aéreas Suramericanas Kalitta Charters Total Linhas Aereas
Produced	1962–1984
Number built	1,832^[3]

The only trijet aircraft to be produced by Boeing, the 727 is powered by Pratt & Whitney JT8D low-bypass turbofans below a T-tail, one on each side of the rear fuselage and a center one fed through an S-duct. It shares its six-abreast upper fuselage cross-section and cockpit with the 707. The 133 ft (40.5 m) long 727-100 typically carries 106 passengers in two classes over 2,250 nmi (4,170 km), or 129 in a single class. Launched in 1965, the stretched 727-200 flew in July 1967 and entered service with Northeast Airlines that December. The 20 ft (6.1 m) longer variant typically carries 134 passengers in two classes over 2,550 nmi (4,720 km), or 155 in a single class. Besides the airliner accommodation, a freighter and a Quick Change convertible version were offered.

The 727 was used for many domestic flights and on many international flights within its range. Airport noise regulations have led to hush kit installations. Its last commercial passenger flight was in January 2019. It was succeeded by the 757-200 and larger variants of the 737. As of February 2022^[update], a total of 38 Boeing 727s were in commercial service. There have been 118 fatal incidents involving the Boeing 727. Production ended in September 1984 with 1,832 having been built.

Development

 

Production of the 727

 

Three-crew cockpit

The Boeing 727 design was a compromise among United Airlines, American Airlines, and Eastern Air Lines; each of the three had developed requirements for a jet airliner to serve smaller cities with shorter runways and fewer passengers.^[4] United Airlines requested a four-engine aircraft for its flights to high-altitude airports, especially its hub at Stapleton International Airport in Denver, Colorado.^[4] American Airlines, which was operating the four-engined Boeing 707 and Boeing 720, requested a twin-engined aircraft for efficiency. Eastern Airlines wanted a third engine for its overwater flights to the Caribbean, since at that time twin-engine commercial flights were limited by regulations to routes with 60-minute maximum flying time to an airport (see ETOPS). Eventually, the three airlines agreed on a trijet design for the new aircraft.^[4]

In 1959, Lord Douglas, chairman of British European Airways (BEA), suggested that Boeing and de Havilland Aircraft Company (later Hawker Siddeley) work together on their trijet designs, the 727 and D.H.121 Trident, respectively.^[5] The two designs had a similar layout, the 727 being slightly larger. At that time Boeing intended to use three Allison AR963 turbofan engines, license-built versions of the Rolls-Royce RB163 Spey used by the Trident.^[6][7] Boeing and de Havilland each sent engineers to the other company's locations to evaluate each other's designs, but Boeing eventually decided against the joint venture.^[8] De Havilland had wanted Boeing to license-build the D.H.121, while Boeing felt that the aircraft needed to be designed for the American market, with six-abreast seating and the ability to use runways as short as 4,500 feet (1,400 m).^[9]

In 1960, Pratt & Whitney was looking for a customer for its new JT8D turbofan design study, based on its J52 (JT8A) turbojet,^[10] while United and Eastern were interested in a Pratt & Whitney alternative to the RB163 Spey.^[11] Once Pratt & Whitney agreed to go ahead with development of the JT8D, Eddie Rickenbacker, chairman of the board of Eastern, told Boeing that the airline preferred the JT8D for its 727s. Boeing had not offered the JT8D, as it was about 1,000 lb (450 kg) heavier than the RB163, though slightly more powerful; the RB163 was also further along in development than the JT8D. Boeing reluctantly agreed to offer the JT8D as an option on the 727, and it later became the sole powerplant.^[12]

With high-lift devices^[13] on its wing, the 727 could use shorter runways than most earlier jets (e.g. the 4800-ft runway at Key West International Airport).

Later 727 models were stretched to carry more passengers^[14] and replaced earlier jet airliners such as the Boeing 707 and Douglas DC-8, as well as aging propeller airliners such as the DC-4, DC-6, DC-7, and the Lockheed Constellations on short- and medium-haul routes.

For over a decade, more 727s were built per year than any other jet airliner; in 1984, production ended with 1,832 built^[3] and 1,831 delivered, the highest total for any jet airliner until the 737 surpassed it in the early 1990s.^[15]

Design

 

Diagram of the 727 with engine 2 S-duct in red

 

A Northwest Airlines 727 tail and rear airstairs

The airliner's middle engine (engine 2) at the very rear of the fuselage gets air from an inlet ahead of the vertical fin through an S-shaped duct.^[16] This S-duct proved to be troublesome in that flow distortion in the duct induced a surge in the centerline engine on the take-off of the first flight of the 727-100.^[17] This was fixed by the addition of several large vortex generators in the inside of the first bend of the duct.

 

Six-abreast seating in an Iran Aseman Airlines Boeing 727

The 727 was designed for smaller airports, so independence from ground facilities was an important requirement. This led to one of the 727's most distinctive features: the built-in airstair that opens from the rear underbelly of the fuselage, which initially could be opened in flight.^[13] Hijacker D. B. Cooper used this hatch when he parachuted from the back of a 727, as it was flying over the Pacific Northwest. Boeing subsequently modified the design with the Cooper vane so that the airstair could not be lowered in flight.^[18] The design included an auxiliary power unit (APU), which allowed electrical and air-conditioning systems to run independently of a ground-based power supply, and without having to start one of the main engines. An unusual design feature is that the APU is mounted in a hole in the keel beam web, in the main landing gear bay.^[17] The 727 is equipped with a retractable tailskid that is designed to protect the aircraft in the event of an over-rotation on takeoff. The 727's fuselage has an outer diameter of 148 inches (3.8 m). This allows six-abreast seating (three per side) and a single aisle when 18-inch (46 cm) wide coach-class seats are installed. An unusual feature of the fuselage is the 10-inch (25 cm) difference between the lower lobe forward and aft of the wing as the higher fuselage height of the center section was simply retained towards the rear.

Nosewheel brakes were available as an option to reduce braking distance on landing, which provided reduction in braking distances of up to 150 m (490 ft).^[19]

The 727 proved to be such a reliable and versatile airliner that it came to form the core of many startup airlines' fleets. The 727 was successful with airlines worldwide partly because it could use smaller runways while still flying medium-range routes. This allowed airlines to carry passengers from cities with large populations, but smaller airports to worldwide tourist destinations. One of the features that gave the 727 its ability to land on shorter runways was its clean wing design.^[13] With no wing-mounted engines, leading-edge devices (Krueger, or hinged, flaps on the inner wing and extendable leading edge slats out to the wingtip) and trailing-edge lift enhancement equipment (triple-slotted,^[20] fowler flaps) could be used on the entire wing. Together, these high-lift devices produced a maximum wing lift coefficient of 3.0 (based on the flap-retracted wing area).^[17] The 727 was stable at very low speeds compared to other early jets, but some domestic carriers learned after review of various accidents that the 40-degree flap setting could result in a higher-than-desired sink rate or a stall on final approach.^[21] These carriers' Pilots' Operation Handbooks disallowed using more than 30° of flaps on the 727, even going so far as installing plates on the flap lever slot to prevent selection of more than 30° of flaps.

Noise

 

Stage 3 hush kit mixer for the
JT8D-1 through -17 engines

The 727 is one of the noisiest commercial jetliners, categorized as Stage 2 by the U.S. Noise Control Act of 1972, which mandated the gradual introduction of quieter Stage 3 aircraft. The 727's JT8D jet engines use older low-bypass turbofan technology, whereas Stage 3 aircraft use the more efficient and quieter high-bypass turbofan design. When the Stage 3 requirement was being proposed, Boeing engineers analyzed the possibility of incorporating quieter engines on the 727. They determined that the JT8D-200 engine could be used on the two side-mounted pylons. The JT8D-200 engines are much quieter than the original JT8D-1 through -17 variant engines that power the 727, as well as more fuel efficient due to the higher bypass ratio, but the structural changes to fit the larger-diameter engine (49.2 inches (125 cm) fan diameter in the JT8D-200 compared to 39.9 inches (101 cm) in the JT8D-1 through -17) into the fuselage at the number two engine location were prohibitive.^{[citation needed]}

Current regulations require that a 727, or any other Stage 2 noise jetliner in commercial service must be retrofitted with a hush kit to reduce engine noise to Stage 3 levels to continue to fly in U.S airspace. These regulations have been in effect since December 31, 1999. One such hush kit is offered by FedEx,^[22] and has been purchased by over 60 customers.^[23] Aftermarket winglet kits, originally developed by Valsan Partners and later marketed by Quiet Wing Corp. have been installed on many 727s to reduce noise at lower speeds, as well as to reduce fuel consumption.^[24] In addition, Raisbeck Engineering developed packages to enable 727s to meet the Stage 3 noise requirements. These packages managed to get light- and medium-weight 727s to meet Stage 3 with simple changes to the flap and slat schedules. For heavier-weight 727s, exhaust mixers must be added to meet Stage 3.^[24] American Airlines ordered and took delivery of 52 Raisbeck 727 Stage 3 systems. Other customers included TWA, Pan Am, Air Algérie, TAME, and many smaller airlines.^[25][26]

Since September 1, 2010, 727 jetliners (including those with a hush kit) are banned from some Australian airports because they are too loud.^[27]

Operational history

 

A FedEx Express 727-233 departs Portland International Airport

 

Delta Air Lines retired its last 727 from scheduled service in April 2003

 

Northwest Airlines retired its last 727 from charter service in June 2003

In addition to domestic flights of medium range, the 727 was popular with international passenger airlines.^[14] The range of flights it could cover (and the additional safety added by the third engine) meant that the 727 proved efficient for short- to medium-range international flights in areas around the world.

The 727 also proved popular with cargo and charter airlines. FedEx Express introduced 727s in 1978.^[28] The 727s were the backbone of its fleet until the 2000s; FedEx began replacing them with Boeing 757s in 2007.^[28] Many cargo airlines worldwide employ the 727 as a workhorse, since, as it is being phased out of U.S. domestic service because of noise regulations, it becomes available to overseas users in areas where such noise regulations have not yet been instituted. Charter airlines Sun Country, Champion Air, and Ryan International Airlines all started with 727 aircraft.^{[citation needed]}

The 727 had some military uses, as well. Since the aft stair could be opened in flight, the Central Intelligence Agency used them to drop agents and supplies behind enemy lines in Vietnam.^[29] In early 1988, The Iraqi Air Force modified a Boeing 727 by fitting it with Thomson-CSF TMV-018 Syrel pods for ESM and Raphael-TH pods with side looking radar. Known as 'Faw-727', it was reportedly used as an ELINT platform in the Invasion of Kuwait in 1990 (during which it was briefly locked on by a Kuwaiti Mirage F1 on August 2) and the subsequent Iraqi monitoring of Coalition forces during Desert Shield.^[30][31]

The 727 has proven to be popular where the airline serves airports with gravel, or otherwise lightly improved, runways. The Canadian airline First Air, for example, previously used a 727-100C to serve the communities of Resolute Bay and Arctic Bay in Nunavut, whose Resolute Bay Airport and former Nanisivik Airport both have gravel runways. The high-mounted engines greatly reduce the risk of foreign object damage.^{[citation needed]}

A military version, the Boeing C-22, was operated as a medium-range transport aircraft by the Air National Guard and National Guard Bureau to airlift personnel. A total of three C-22Bs were in use, all assigned to the 201st Airlift Squadron, District of Columbia Air National Guard.^[32]

At the start of the 21st century, the 727 remained in service with a few large airlines. Faced with higher fuel costs, lower passenger volumes due to the post-9/11 economic climate, increasing restrictions on airport noise, and the extra expenses of maintaining older planes and paying flight engineers' salaries, most major airlines phased out their 727s; they were replaced by twin-engined aircraft, which are quieter and more fuel-efficient. Modern airliners also have a smaller flight deck crew of two pilots, while the 727 required two pilots and a flight engineer. Delta Air Lines, the last major U.S. carrier to do so, retired its last 727 from scheduled service in April 2003. Northwest Airlines retired its last 727 from charter service in June 2003. Many airlines replaced their 727s with either the 737-800 or the Airbus A320; both are close in size to the 727-200. As of July 2013^[update], a total of 109 Boeing 727s were in commercial service with 34 airlines;^[33] three years later, the total had fallen to 64 airframes in service with 26 airlines.^[34]

On March 2, 2016, the first 727 produced (N7001U), which first flew on February 9, 1963, made a flight to a museum after extensive restoration. The 727-100 had carried about three million passengers during its years of service. Originally a prototype, it was later sold to United Airlines, which donated it to the Museum of Flight in Seattle in 1991. The jet was restored over 25 years by the museum and was ferried from Paine Field in Everett, Washington to Boeing Field in Seattle, where it was put on permanent display at the Aviation Pavilion.^[35][36][37] The Federal Aviation Administration granted the museum a special permit for the 15-minute flight. The museum's previous 727-223, tail number N874AA, was donated to the National Airline History Museum in Kansas City and was planned to be flown to its new home once FAA ferry approval was granted.^[38] After a series of financial problems with the restoration, N874AA was seized by Boeing Field for nonpayment of storage fees in 2021 and subsequently broken up and scrapped.^[39]

On January 13, 2019, the last commercial passenger flight of a Boeing 727 was flown between Zahedan and Tehran by Iran Aseman Airlines.^[2]

Variants

Data from: Boeing Aircraft since 1916^[40]

The two series of 727 are the initial -100 (originally only two figures as in -30), which was launched in 1960 and entered service in February 1964, and the -200 series, which was launched in 1965 and entered service in December 1967.

727-100

 

The initial 727-100 (from Lufthansa here) is 133 ft (41 m) long.

 

The sole C-22A.

The first 727-100 (N7001U) flew on February 9, 1963.^[35] FAA type approval was awarded on December 24 of that year, with initial delivery to United Airlines on October 29, 1963, to allow pilot training to commence. The first 727 passenger service was flown by Eastern Air Lines on February 1, 1964, between Miami, Washington, DC, and Philadelphia.

A total of 571 Boeing 727-00/100 series aircraft were delivered (407 -100s, 53 -100Cs, and 111 -100QCs), the last in October 1972. One 727-100 was retained by Boeing, bringing total production to 572.^[41]

The -100 designation was assigned retroactively to distinguish the original short-body version. Actual aircraft followed a "727-00" pattern. Aircraft were delivered for United Airlines as 727-22, for American Airlines as 727-23, and so on (not -122, -123, etc.) and these designations were retained even after the advent of the 727-200.

727-100C

Convertible passenger cargo version, additional freight door and strengthened floor and floor beams, three alternative fits:

• 94 mixed-class passengers
• 52 mixed-class passengers and four cargo pallets (22,700 pounds; 10,300 kg)
• Eight cargo pallets (38,000 pounds; 17,000 kg)

727-100QC

QC stands for Quick Change. This is similar to the convertible version with a roller-bearing floor for palletised galley and seating and/or cargo to allow much faster changeover time (30 minutes).

 

A 727-100QF of UPS Airlines. The air intake for the #2 engine has a distinctive "hump" on converted aircraft.

727-100QF

QF stands for Quiet Freighter. A cargo conversion for United Parcel Service, these were re-engined with Stage 3-compliant Rolls-Royce Tay turbofans.

Boeing C-22A

A single 727-30 acquired from the Federal Aviation Administration, this aircraft was originally delivered to Lufthansa. It served mostly with United States Southern Command flying from Panama City / Howard Air Force Base.

Boeing C-22B

Four 727-35 aircraft were acquired from National Airlines by the United States Air Force for transporting Air National Guard and National Guard personnel.

727-200

 

The 727-200 (here from Ariana Afghan Airlines) is 20 ft (6.1 m) longer.

A stretched version of the 727-100, the -200 is 20 feet (6.1 m) longer (153 feet 2 inches;46.69 m) than the -100 (133 feet 2 inches;40.59 m). A 10-ft (3-m) fuselage section ("plug") was added in front of the wings and another 10-ft fuselage section was added behind them. The wing span and height remain the same on both the -100 and -200 (108 and 34 feet (33 and 10 m), respectively). The original 727-200 had the same maximum gross weight as the 727-100; however, as the aircraft evolved, a series of higher gross weights and more powerful engines were introduced along with other improvements, and from line number 881, 727-200s are dubbed -200 Advanced. The aircraft gross weight eventually increased from 169,000 to 209,500 pounds (76,700 to 95,000 kg) for the latest versions. The dorsal intake of the number-two engine was also redesigned to be round in shape, rather than oval as it was on the -100 series.

The first 727-200 flew on July 27, 1967, and received FAA certification on November 30, 1967. The first delivery was made on December 14, 1967, to Northeast Airlines. A total of 310 727-200s were delivered before the -200 was replaced on the production line by the 727-200 Advanced in 1972.

727-200C

A convertible passenger cargo version; only one was built.

727-200 Advanced

The Advanced version of the 727-200 was introduced in 1970.^[42] It featured powerful engines, fuel capacity and MTOW (185,800–210,000 lb or 84.3–95.3 t) increased the range from 1,930 to 2,550 nmi (3,570 to 4,720 km) or by 32%.^[43] After the first delivery in mid-1972, Boeing eventually raised production to more than a hundred per year to meet demand by the late 1970s. Of the passenger model of the 727-200 Advanced, a total of 935 were delivered, after which it had to give way to a new generation of aircraft.

 

Freighter cargo hold

727-200F Advanced

A freighter version of the 727-200 Advanced became available in 1981, designated the Series 200F Advanced. Powered by Pratt & Whitney JT8D-17A engines, it featured a strengthened fuselage structure, an 11 ft 2 in (3.40 m) by 7 ft 2 in (2.18 m) forward main deck freight door, and a windowless cabin. Fifteen of these aircraft were built, all for Federal Express. This was the last production variant of the 727 to be developed by Boeing; the last 727 aircraft completed by Boeing was a 727-200F Advanced.

 

The "Super 27" re-engine has larger JT8D-200 side engines

Super 27

Certificated by Valsan Partners in December 1988 and marketed by Goodrich from 1997, the side engines are replaced by more efficient, quieter JT8D-217C/219, and the center engine gains a hush kit for $8.6 million (but loses the thrust reverser) (2000): fuel consumption is reduced by 10-12%, range and restricted airfield performance are improved.^[44]

Boeing C-22C

A single 727-212 aircraft was operated by the USAF.

Proposed

727-300

A proposed 169 seat version was developed in consultation with United Airlines in 1972, which initially expressed an interest in ordering 50 aircraft. There was also interest from Indian Airlines for a one-class version with 180 seats. The fuselage would have been lengthened by 18 feet (5.5 m) and the undercarriage strengthened. The three engines would have been replaced by two more powerful JT8D-217 engines under the T tail.^[45][46] Many cockpit components would have been common with 737-200 and improved engine management systems would have eliminated the need for the flight engineer. United did not proceed with its order and Indian Airlines instead ordered the larger Airbus A300, so the project was cancelled in 1976.^[47]

727-400

A concept with a 155 feet (47 m) fuselage and two high bypass turbofan engines under the wings (but retaining the T tail) was proposed in 1977. More compact systems, a redesign of the internal space and removing the need for the flight engineer would have increased the capacity to 189 seats in two class configuration. After only a few months the concept was developed into the Boeing 7N7 design which eventually became the Boeing 757.^[48]

Other variants

Faw-727

A Boeing 727 that was reportedly modified by Iraq in early 1988 to serve as an ELINT platform. It was used during the Invasion of Kuwait and Operation Desert Shield.^{[30] [31]}

Operators

 

Iran Aseman Airlines operated the last scheduled 727 passenger flight in 2019.

Main article: List of Boeing 727 operators

Commercial operators

 

Kalitta Charters is operating four 727 in its fleet.

As of February 2022^[update], there were 35 Boeing 727s in commercial service. Iran Aseman Airlines, the last passenger airline operator, made the last scheduled 727 passenger flight on 13 January 2019.^[49] These operators have three or more aircraft for cargo as of July 2022:^[50]

• Kalitta Charters (3)
• Aerosucre (3)

T2 Aviation Ltd uses 2 modified former FedEx 727-200 freighters, operated by 2 Excel Aviation, equipped with oil dispersal tanks and spray booms to respond to oil spills.^[51]

Zero Gravity Corporation uses a modified 727-200 in reduced-gravity passenger carrying operations.^[52]

Uruguayan cargo carrier Air Class Cargo SA (http://www.airclasscargo.com/) uses two 727-200s: active registration numbers CX-CLC and CX-CAR.

USA Jet Airlines out of Willow Run, MI (KYIP) operates two Ex-Capital Cargo Boeing 727-200 freighters on ad-hoc cargo operations.

Government, military, and other operators

 

Burkina Faso 727

In addition, the 727 has seen sporadic government use, having flown for the Belgian, Yugoslav, Mexican, New Zealand, and Panama air forces, among the small group of government agencies that have used it.

  Afghanistan

• Afghan Air Force – Three being acquired from Ariana Afghan Airlines.^[53] Only 1 remains in service.^[54]

  Benin

• Military of Benin (1)

  Bolivia

• Bolivian Air Force (Transporte Aereo Militar) (1)

  Burkina Faso

• Burkina Faso Air Force (1)

  Colombia

• Colombian government
• Colombian Air Force (2)

  Democratic Republic of the Congo

• Force Aérienne du Congo (4)

  Djibouti

• Djibouti Air Force (2)^[55]

  Ecuador

• Ecuadorian Air Force (1)

  Iraq

• Iraqi Air Force (Pre 2003), Faw-727 ELINT aircraft (1)
• Iraqi government, Salah Aldin (1)

  Ivory Coast

• Government of Ivory Coast^[56]

  Mexico

• Mexican Air Force (5) retired in 2017
• Mexico National Guard (3)

  New Zealand

• Royal New Zealand Air Force (3) retired in 2003

  United Kingdom

• Oil Spill Response Limited^[2]

  United States

• United States Air Force – formerly used as a military transport, designated the C-22.

Private aircraft

A number of 727s have been outfitted for use as private aircraft, especially since the early 1990s when major airlines began to eliminate older 727-100 models from their fleet.^[57] Donald Trump traveled in a former American Airlines 727-100 with dining room, bedroom and shower facilities known as Trump Force One before upgrading to a larger Boeing 757 in 2009;^[58] Peter Nygård acquired a 727-100 for private use in 2005.^[59] American financier Jeffrey Epstein owned a private 727 nicknamed the "Lolita Express".^[60] The Gettys bought N311AG from Revlon in 1986, and Gordon Getty acquired the aircraft in 2001.^[61]

Accidents and incidents

Main article: List of accidents and incidents involving the Boeing 727

As of January 2019^[update], a total of 351 incidents involving 727s had occurred, including 119 hull-loss accidents^[62] resulting in a total of 4,211 fatalities.^[62]

Orders and deliveries

Year	Total	1984	1983	1982	1981	1980	1979	1978	1977	1976	1975	1974	1973
Orders	1,831	0	1	11	38	68	98	125	133	113	50	88	92
Deliveries	1,831	8	11	26	94	131	136	118	67	61	91	91	92

Year	1972	1971	1970	1969	1968	1967	1966	1965	1964	1963	1962	1961	1960
Orders	119	26	48	64	66	125	149	187	83	20	10	37	80
Deliveries	41	33	55	114	160	155	135	111	95	6	0	0

Source: Data from Boeing, through the end of production^[63]

Boeing 727 orders and deliveries (cumulative, by year):

 Orders

 Deliveries

Model summary

Model Series	ICAO code^[64]	Orders	Deliveries
727-100	B721/R721^[b]	407	407
727-100C	B721	164	164
727-200	B722	1245	1245
727-200F	B722/R722^[b]	15	15
Total		1831	1831

Source: Boeing^[63]

Aircraft on display

There are a comparatively large number of surviving retired 727s, largely as a result of donation by FedEx of 84 of them to various institutions. The vast majority of the aircraft were given to university aviation maintenance programs. All but 5 are located within the United States.^[65]

• N7001U – 727-022 on static display at the Museum of Flight in Seattle, Washington. It was the first 727 completed. It departed from Paine Field in Everett, Washington and landed at the museum on March 2, 2016.^[66][67]
• N7004U – 727-022 in storage at the Pima Air & Space Museum in Tucson, Arizona. It was the first 727 delivered to a customer and the first to make a commercial flight. It is currently awaiting restoration.^[68]
• N7017U – 727 on static display at the Museum of Science and Industry in Chicago, Illinois. It was donated by United Airlines. It features cut away sections showing airplane framework and lavatory, cockpit view, and a few rows of seating.^[69][70]
• N186FE – 727-100 on static display at Owens Community College in Perrysburg, Ohio. It formerly operated by FedEx and donated by the company in 2007.^[71][72]
• N199FE – 727-173C on static display at the Kansas Aviation Museum in Wichita, Kansas. It was formerly operated by FedEx as N199FE.^[73][74]
• N113FE Jarrod – 727-022C in storage at the National Museum of Commercial Aviation in Atlanta, Georgia. It was formerly operated by FedEx as N113FE, and by United Airlines before that as N7437U.^[75]
• N265SE Paul – 727-200 on static display at the Florida Air Museum in Lakeland, Florida. It was formerly operated by FedEx.^[76][77]
• N492FE Two Bears – 727-227 on static display with the University of Alaska at Merrill Field in Anchorage, Alaska. It was formerly operated by FedEx and was donated by the company on February 26, 2013.^{[78][79][80][81]}
• N874AA – 727-223 previously on display at the Museum of Flight and later stored for the Airline History Museum at Boeing Field in Seattle, Washington.^[82] The aircraft was eventually seized by King County (Washington) for non-payment of rent and storage fees, declared non-airworthy, and scrapped at Boeing Field in November 2021.^[83]
• G-BNNI Lady Patricia – 727-276 last flown by Sabre Airways in 2000. Purchased by 727 Communications, an advertising company in Skanderborg, Denmark, it now serves as a conference room and billboard at their offices.^[84][85]
• VP-CMN "PYTCHAir" - 727-46 is located in Bristol, UK and was purchased by technology investor Johnny Palmer for his media company PYTCH. The fuselage is resting atop a series of shipping containers and was transported in February 2021.^[86][87][88]
• XA-RRA – 727-14 preserved in Mexicana de Aviación livery at Parque Metropolitano in León, Guanajuato, Mexico.^[89]
• XC-FPA – 727-264/Adv, last operated by the Mexican Federal Police, on display in Parque Tangamanga, San Luis Potosí City, Mexico.^[90]
• A nose section of 727 on static display at the Museum of Flying in Santa Monica, California, it was donated by FedEx after retirement, it underwent a complete restoration courtesy in fall of 2018.^[91]
• 727-2F parked on overflow ramp on Cargo Row between FedEx Ramp and DHL/UPS ramp at MCI(Kansas City International), used for airport Fire Services training as well as most pax carriers for de-ice training platform. Donated by FedEx Express.
• 727-2F used as static platform trainer for Aircraft MX students at Tennessee College of Applied Sciences, Memphis International Airport(MEM). Located on east side of airport near runway 9-27. Donated by FedEx Express.
• 727-2F used as static platform for Aircraft MX and cockpit procedure training by students at Middle Tennessee State University. Murfreesboro, TN municipal airport(MBT- FAA and ICAO, no IATA identification). Donated, and flown from MEM, by 3 of the most senior and experienced 727 FedEx flight crew members, making use of the majority of the 3,898ft(1,188M) runway.

Specifications

 

A comparison of the different 727 variants

Boeing 727 Characteristics^[92]

Variant	727-100	727-200
Flight crew^[93]	three: pilot, copilot, and flight engineer
Two-class seats	106: 16F@38", 90Y@34"	134: 20F@38", 114Y@34"
One-class seats	125@34"	155@34"
Exit limit^[93]	131	189
Length	133 ft 2 in / 40.59 m	153 ft 2 in / 46.68 m
Height	34 ft 3 in / 10.44 m	34 ft 11 in / 10.65 m
Cabin width	140 in / 3.56 m
Wingspan	108 ft / 32.92 m
Wing^[43]	1,650 sq ft (153 m^2), 32° sweep
MTOW	169,000 lb / 76,700 kg	172,000 lb / 78,100 kg Adv. 209,500 lb / 95,100 kg
OEW	87,696 lb / 39,800 kg	97,650 lb / 44,330 kg Adv. 100,700 lb / 45,720 kg
Fuel capacity	7,680 gal / 29,069 L	8,090 US gal / 30,620 L Adv. 10,585 US gal / 40,060 L
Engines ×3	Pratt & Whitney JT8D-1/7/9	JT8D-7/9/11 (Adv.: -9/15/17/17R)
Thrust ×3	14,000–14,500 lbf (62–64 kN)	14,000–15,000 lbf (62–67 kN) Adv. 14,500–17,400 lbf (64–77 kN)
Range^[c]	2,250 nmi (4,170 km)	1,900 nmi (3,500 km) Adv. 2,550 nmi (4,720 km)
Take-off^[d]	8,300 ft (2,500 m)	8,400 ft (2,600 m) Adv. 10,100 ft (3,100 m)
MMO^[93]	Mach 0.9 (961 km/h; 519 kn)
Cruise	495–518 kn / 917–960 km/h^[94]	467–515 kn / 865–953 km/h^[95]
Ceiling^[93]	42,000 ft (13,000 m)

See also

•  Aviation portal
•  United States portal

• 2012 Boeing 727 crash experiment
• Notable appearances in media

Related development

• Boeing 707
• Boeing 737
• Boeing 7J7
• Boeing 757

Aircraft of comparable role, configuration, and era

• Hawker Siddeley Trident
• BAC One-Eleven
• McDonnell Douglas DC-9
• Tupolev Tu-154

Related lists

• List of civil aircraft
• List of jet airliners

Notes

1. Retired from airline passenger use in January 2019^[2]
2. R721/R722 refers to Super 27 variants.
3. Two-class passengers
4. MTOW, SL, ISA

References

1. "727 Commerciat transport : Historical Snapshot". Boeing.
2. Guy, Jack (January 22, 2019). "Boeing's famous trijet 727 makes last commercial flight". CNN.
3. . Boeing Commercial Airplanes. Archived from the original on May 3, 2012. Retrieved May 14, 2012. By January 1983, orders reached 1,831. One Boeing-owned test airplane brought the grand total to 1,832.
4. "Commercial Jets". Modern Marvels. Season A149. January 16, 2001. approx. 15 minutes in.
5. Connors 2010, p. 355
6. Technical Editor (December 16, 1960). "Analysing the 727". Flight. Vol. 78, no. 2071. Retrieved April 1, 2015 – via Flightglobal Archive. {{cite magazine}}: |author= has generic name (help)
7. Alastair Pugh (December 30, 1960). "Boeing's Trimotor". Flight. Vol. 78, no. 2073. Retrieved April 1, 2015 – via Flightglobal Archive.
8. Connors 2010, p. 357
9. "Talking to Mr Beall: Boeing's Senior Vice-President in London". Flight. Reed Business Information. October 4, 1960. Retrieved March 4, 2011.
10. Connors 2010, pp. 348–349
11. Connors 2010, p. 350
12. Connors 2010, p. 352
13. Eden, Paul. (Ed). Civil Aircraft Today. 2008: Amber Books, pp. 72–3.
14. Eden 2008, pp. 74–5.
15. Norris and Wagner. Modern Boeing Jetliners, pp. 12–3. Motorbooks International, 1999.
16. ". Aircraft & Powerplant Corner."
17. Case Study in Aircraft Design; the Boeing 727, American Institute of Aeronautics and Astronautics Professional Study Series, September 1978.
18. Bruce Schneier (2003). Beyond Fear: Thinking Sensibly about Security in an Uncertain World. p. 82. ISBN 0-387-02620-7.
19. Lufthansa. Operating Manual Boeing 727, pp. 1.4.32-1, 4.3.4-2.
20. . Boeing. Archived from the original on May 24, 2011. Retrieved 2011-03-16.
21. "Five decades ago, Boeing's new 727 jet also had a terrible start". Reuters. March 25, 2019. Retrieved June 7, 2022.
22. "Boeing 727 - Stage 3 Kits". fedex.com. Retrieved April 1, 2015.
23. "Case Study - Plane Quiet". fedex.com. Retrieved April 1, 2015.
24. (PDF). Flight International. Vol. 159, no. 4789. July 13, 2001. p. 41. Archived from the original (PDF) on April 22, 2016.
25. James Raisbeck. . Archived from the original on June 27, 2012. Retrieved July 25, 2011.
26. . Archived from the original on June 3, 2011. Retrieved July 25, 2011.
27. Creedy, Steve (March 30, 2010). "Noisy Boeing 727s will be banned". News Corporation. Retrieved March 30, 2010.
28. . FedEx.com. Archived from the original on September 15, 2014. Retrieved September 15, 2014.
29. Himmelsbach & Worcester 1986, p. 43.
30. Cooper, Tom (2021). In the claws of the Tomcat - US Navy F-14 Tomcats in Air Combat against Iran and Iraq, 1987-2000. Helion & Company Limited. p. 28. ISBN 978-1-915070-23-4.
31. Cooper, Tom (2019). Desert Storm - Volume 1: The Iraqi Invasion of Kuwait and Operation Desert Shield 1990-1991. pp. 24, 26, 49, 54, 107. ISBN 978-1-915070-05-0.
32. Frawley, Gerard (2002). The International Directory of Military Aircraft, 2002–2003. Fyshwick, ACT, Australia: Aerospace Publications Pty Ltd. ISBN 1-875671-55-2.
33. "World Airliner Census". Flight International. Vol. 184, no. 5403. August 13, 2013. pp. 40–58 [49].
34. FlightGlobal (2017). World Airliner Census (PDF). p. 34. Retrieved January 1, 2018.
35. Farris, Brandon; King, Royal Scott. . CNN. Archived from the original on March 4, 2016. Retrieved March 4, 2016.
36. Siebenmark, Jerry (March 2, 2016). . Archived from the original on March 6, 2016. Retrieved March 4, 2016.
37. Siebenmark, Jerry (March 3, 2016). "Wichitans made parts for, flew on Boeing 727". Retrieved March 4, 2016.
38. . National Airline History Museum. Archived from the original on March 14, 2016. Retrieved March 14, 2016.
39. "'Absolutely tragic.' The grisly demolition at Seattle's Boeing Field of an old 727". The Seattle Times. November 18, 2021. Retrieved January 20, 2022.
40. Bowers, Peter M. (June 1989). Boeing Aircraft since 1916. USA: Naval Institute Press. pp. 481–492. ISBN 978-3-8228-9663-1.
41. Airclaims Jet Programs 1995
42. Gilchrist, p.62
43. "727-100/200" (PDF). Startup. Boeing. 2007. Archived (PDF) from the original on October 9, 2022.
44. (PDF). Flight International. Vol. 159, no. 4789. July 13, 2001. p. 42. Archived from the original (PDF) on April 15, 2019.
45. "American Aviation Historical Society Journal". American Aviation Historical Society. 1999: 121. {{cite journal}}: Cite journal requires |journal= (help)
46. Mark Wagner (1998). Boeing Jetliners. Barnes & Noble. p. 67. ISBN 1610607066.
47. "Asia Defense Journal". Vikrant Group. 1977. p. 22.
48. "Shortlines". Aviation Week & Space Technology. 107: 4. 1977.
49. Falcus, Matt (January 14, 2019). "Iran Aseman Retires Last Scheduled Boeing 727". Airport Spotting Blog. Retrieved January 15, 2019.
50. . Flightglobal.com. July 2018. Archived from the original on November 6, 2018. Retrieved August 21, 2018.
51. . 2Excel Aviation. Archived from the original on August 28, 2018. Retrieved August 27, 2018.
52. . Archived from the original on October 7, 2019. Retrieved October 16, 2019.
53. "Afghan AF acquires 3 Boeing 727s". Air Forces Monthly. Key Publishing: 30. December 2014.
54. "World Air Forces 2018". Flightglobal Insight. 2018. Retrieved December 4, 2017.
55. "Djibouti Air Force gets two Y-12s; Dauphin helicopters". defenceWeb. 2016. Retrieved July 19, 2016.
56. Hesse, Rene (January 2012). "New Boeing 727 for Côte d'Ivoire". Air International. Vol. 82, no. 1. p. 20. ISSN 0306-5634.
57. "REBUILDING SECOND-HAND 727'S". The New York Times. November 7, 1981. ISSN 0362-4331. Retrieved January 16, 2017.
58. "Inside Donald Trump's private jet - The exterior (1) - CNNMoney.com". money.cnn.com. Retrieved January 16, 2017.
59. . corporate.nygard.com. Archived from the original on December 30, 2017. Retrieved January 16, 2017.
60. Ostler, Catherine. "Jeffrey Epstein: The Sex Offender Who Mixes With Princes and Premiers". Newsweek. Retrieved July 7, 2019.
61. "N311AG | Boeing 727-17 | 20512".
62. "Boeing 727 Accident summary", Aviation-Safety.net, May 5, 2007. Retrieved July 13, 2008.
63. . Boeing Commercial Airplanes. Archived from the original on April 19, 2020. Retrieved December 10, 2010.
64. "ICAO Document 8643". International Civil Aviation Organization. Retrieved June 20, 2017.
65. Bostick, Brian (November 24, 2014). . Aviation Week Network. Penton. Archived from the original on April 7, 2017. Retrieved April 6, 2017.
66. "Boeing 727-022". The Museum of Flight. The Museum of Flight. Retrieved March 31, 2017.
67. Farris, Brandon (March 3, 2016). . Airways News. Airways International, Inc. Archived from the original on March 6, 2016. Retrieved March 31, 2017.
68. "Boeing 727-100". Pima Air & Space. Retrieved June 4, 2021.
69. "United Airlines Boeing 727." Chicago Museum of Science and Industry. Retrieved: 19 December 2016.
70. "Airframe Dossier - Boeing 727-22, c/n 18309, c/r N7017U". Aerial Visuals. AerialVisuals.ca. Retrieved March 31, 2017.
71. . Owens Community College. Owens Community College. April 19, 2007. Archived from the original on March 31, 2017. Retrieved March 31, 2017.
72. "Airframe Dossier - Boeing B727 / C-22, c/n 18872, c/r N186FE". Aerial Visuals. AerialVisuals.ca. Retrieved March 31, 2017.
73. "Boeing 727". Kansas Aviation Museum. Retrieved March 31, 2017.
74. "Airframe Dossier - Boeing 727-173C, c/n 19509, c/r N199FE". Aerial Visuals. AerialVisuals.ca. Retrieved March 31, 2017.
75. . National Museum of Commercial Aviation. National Museum of Commercial Aviation. Archived from the original on April 1, 2017. Retrieved March 31, 2017.
76. . Sun 'n Fun. SUN 'n FUN. Archived from the original on March 14, 2017. Retrieved March 31, 2017.
77. . Planespotters.net. Planespotters.net. Archived from the original on April 1, 2017. Retrieved March 31, 2017.
78. Mondor, Colleen (May 31, 2016). "Small Alaska airport makes room for FedEx 727". adn.com. Alaska Dispatch Publishing. Retrieved March 31, 2017.
79. . Green & Gold News. February 25, 2013. Archived from the original on April 1, 2017. Retrieved April 1, 2017.
80. Erickson, Evan (March 12, 2013). . The Northern Light. Archived from the original on April 1, 2017. Retrieved April 1, 2017.
81. . Planespotters.net. Planespotters.net. Archived from the original on April 1, 2017. Retrieved April 1, 2017.
82. "BOEING 727-223". Airline History Museum. Retrieved December 4, 2017.
83. "Former American Airlines 727 Scrapped at Boeing Field". November 12, 2021.
84. "VH-TBK Boeing 727-276A". www.aussieairliners.org. Retrieved November 24, 2018.
85. "G-BNNI | Boeing 727-276(Adv) | 727 Communication | Soren Madsen | JetPhotos". JetPhotos. Retrieved November 25, 2018.
86. "Boeing 727 travels to Bristol to be turned into office space". March 4, 2021.
87. "Boeing 727 taken for a drive down the M5". March 2021.
88. "Enormous Boeing plane stops traffic as it is driven on motorway to new home". Daily Mirror. February 28, 2021.
89. "XA-RRA - Boeing 727-14". JetPhotos. Retrieved April 6, 2021.
90. "Civil Database". Scramble. Retrieved April 6, 2021.
91. "Boeing 727 cockpit | Museum of Flying". March 4, 2019. Retrieved March 21, 2021.
92. "727 Airplane Characteristics for Airport Planning" (PDF). Boeing. May 2011. Archived (PDF) from the original on October 9, 2022.
93. (PDF). FAA. February 20, 1991. Archived from the original (PDF) on December 1, 2019. Retrieved December 11, 2016.
94. Gerard Frawley. "727-100 aircraft technical data & specifications". The International Directory of Civil Aircraft.
95. Gerard Frawley. "727-200 aircraft technical data & specifications". The International Directory of Civil Aircraft.

• Connors, Jack (2010). The Engines of Pratt & Whitney: A Technical History. Reston. Virginia: American Institute of Aeronautics and Astronautics. ISBN 978-1-60086-711-8.
• Himmelsbach, Ralph P.; Worcester, Thomas K. (1986). Norjak: The Investigation of D. B. Cooper. West Linn, Oregon: Norjak Project. ISBN 978-0-9617415-0-1.
• Gilchrist, Peter (1996). Modern Civil Aircraft 13: Boeing 727. Shepperton, United Kingdom: Ian Allan Publishing. ISBN 0-7110-2081-7.

External links

 

Wikimedia Commons has media related to:
Boeing 727 (category)

• "727 Commerciat transport : Historical Snapshot". Boeing.
• 727 Datacenter | website dedicated to the history of the Boeing's trijet (http://727datacenter.net/)
• Encyclopedia 727 | Book series with 5 volumes about the Boeing 727. Volume 1 already available (https://www.enciclopedia727.com.br/en)
• 727 prototype on rbogash.com
• Boeing-727.com site
• Fatal Boeing 727 Events on Airsafe.com
• "Boeing jet has new appearance". Spokesman-Review. (Spokane, Washington). (AP photo). November 2, 1962. p. 2B.
• Murdo Morrison (November 28, 2014). "Soldiering on: 10 veteran airliner types still in service". Flightglobal.
• Guy Norris (January 16, 2015). . Aviation Week. From The Archives. Archived from the original on March 21, 2017. Retrieved November 28, 2016.